Hostname: page-component-78c5997874-s2hrs Total loading time: 0 Render date: 2024-11-19T14:13:19.307Z Has data issue: false hasContentIssue false
  • English
  • Français

Anomalous crystallization of hydrogenated amorphous silicon during fast heating ramps

Published online by Cambridge University Press:  03 March 2011

J. Farjas ,
J. Serra-Miralles ,
P. Roura ,
E. Bertran  and
P. Roca i Cabarrocas
J. Farjas
Affiliation:
GRMT, Department of Physics, University of Girona, Campus Montilivi, E17071-Girona, Catalonia, Spain
J. Serra-Miralles
Affiliation:
GRMT, Department of Physics, University of Girona, Campus Montilivi, E17071-Girona, Catalonia, Spain
P. Roura*
Affiliation:
GRMT, Department of Physics, University of Girona, Campus Montilivi, E17071-Girona, Catalonia, Spain
E. Bertran
Affiliation:
FEMAN, Departament de Física Aplicada i Optica, Universitat de Barcelona, E08028-Barcelona, Catalonia, Spain
P. Roca i Cabarrocas
Affiliation:
LPICM (UMR 7647 CNRS) Ecole Polytechnique, 91128 Palaiseau Cedex, France
*
a) Address all correspondence to this author. e-mail: pere.roura@udg.es
Get access

Abstract

Thermal crystallization experiments carried out using calorimetry on several a-Si:H materials with different microstructures are reported. The samples were crystallized during heating ramps at constant heating rates up to 100 K/min. Under these conditions, crystallization takes place above 700 °C and progressively deviates from the standard kinetics. In particular, two crystallization processes were detected in conventional a-Si:H, which reveal an enhancement of the crystallization rate. At 100 K/min, such enhancement is consistent with a diminution of the crystallization time by a factor of 7. In contrast, no systematic variation of the resulting grain size was observed. Similar behavior was also detected in polymorphous silicon and silicon nanoparticles, thus showing that it is characteristic of a variety of hydrogenated amorphous silicon materials.

Keywords

AmorphousDifferential thermal analysis (DTA)Photovoltaic
Type
Rapid Communications
Information
Journal of Materials Research , Volume 20 , Issue 2 , February 2005 , pp. 277 - 281
Copyright
Copyright © Materials Research Society 2005

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

1.Pierson, J.F., Kim, K.S., Jolly, J., and Mencaraglia, D.: Crystallization of n-doped amorphous silicon PECVD films: Comparison between SPC and RTA methods. J. Non-Cryst. Solids 270, 91 (2000).CrossRefGoogle Scholar
2.Technology and Applications of Amorphous Silicon, edited by Street, R.A. (Springer, Berlin, Germany, 2000).CrossRefGoogle Scholar
3.Hatalis, M.K. and Greve, D.W.: Large grain polycrystalline silicon by low temperature annealing of low-pressure chemical vapor deposited amorphous silicon films. J. Appl. Phys. 63, 2260 (1998).CrossRefGoogle Scholar
4.Spinella, C., Lombardo, S., and Priolo, F.: Crystal grain nucleation in amorphous silicon. J. Appl. Phys. 84, 5383 (1998).CrossRefGoogle Scholar
5.Iverson, R.B. and Reif, R.: Recrystallization of amorphized polycrystalline silicon films on SiO2: Temperature dependence of the crystallization parameters. J. Appl. Phys. 62, 1675 (1987).CrossRefGoogle Scholar
6.Masaki, Y., LeComber, P.G., and Fitzgerald, A.G.: Solid phase crystallization of thin films of Si prepared by plansma enhanced chemical vapour deposition. J. Appl. Phys. 74, 129 (1993).CrossRefGoogle Scholar
7.Donovan, E.P., Spaepen, F., Turnbull, D., Poate, J.M., and Jacobson, D.C.: Heat of crystallization and melting point of amorphous silicon. Appl. Phys. Lett. 42, 698 (1983).Google Scholar
8.Farjas, J., Rath, C., Roura, P., and Cabarrocas, P. Roca i: Crystallization kinetics of hydrogenated amorphous silicon thick films by plasma enhanced chemical vapour deposition. Appl. Surf. Sci. 238, 165 (2004).CrossRefGoogle Scholar
9.Voyles, P.M. and Abelson, J.R.: Medium-range order in amorphous silicon measured by fluctuation electron microscopy. Sol. Energy Mater. Sol. Cells 78, 85 (2003).CrossRefGoogle Scholar
10.Bertran, E., Sharma, S.N., Viera, G., Costa, J., St'ahel, P., and Cabarrocas, P. Roca i: Effect of the nanoparticles on the structure and crystallization of amorphous silicon thin films produced by RF glow discharge. J. Mater. Res. 13, 2476 (1998).CrossRefGoogle Scholar
11.Bertran, E., Costa, J., Sardin, G., Campmany, J., Andújar, J.L., and Canillas, A.: Effects of plasma processing on the microstructural properties of Si powders. Plasma Sources Sci. Technol. 3, 348 (1994).Google Scholar
12.Das, D., Farjas, J., Roura, P., Viera, G., and Bertran, E.: Enhancement of oxidation rate of a-Si nanoparticles during dehydrogenation. Appl. Phys. Lett. 79, 3705 (2001).Google Scholar
13.Das, D., Farjas, J., Roura, P., Viera, G., and Bertran, E.: Thermal oxidation of polymer-like amorphous SixCYHWOz nanoparticles. Diamond Relat. Mater. 10, 1295 (2001).CrossRefGoogle Scholar
14.Henderson, D.E.: Thermal-analysis of non-isothermal crystallization kinetics in glass forming liquids. J. Non-Cryst. Solids 30, 301 (1979).CrossRefGoogle Scholar
15.Kumomi, H. and Yonehara, T.: Transient nucleation and manipulation of nucleation sites in solid-state crystallization of a-Si films. J. Appl. Phys. 75, 2884 (1994).CrossRefGoogle Scholar
16.Paul, W., Jones, S.J., and Turner, W.A.: Studies on the structure of a-Ge:H using differential scanning calorimetry, gas evolution on heating and TEM. Philos. Mag. B 63, 247 (1991).CrossRefGoogle Scholar
17.d'Aragona, F. Secco: Dislocation etch for (100) planes in silicon. J. Electrochem. Soc. 119, 948 (1972).CrossRefGoogle Scholar