Hostname: page-component-848d4c4894-ndmmz Total loading time: 0 Render date: 2024-06-10T17:33:49.491Z Has data issue: false hasContentIssue false
  • English
  • Français

Atomic Scale Analysis of Planar Defects in Polycrystalline Diamond

Published online by Cambridge University Press:  11 October 2006

Rolf Erni ,
Bert Freitag ,
Peter Hartel ,
Heiko Müller ,
Peter Tiemeijer ,
Michiel van der Stam ,
Mike Stekelenburg ,
Dominique Hubert ,
Petra Specht  and
Vincente Garibay-Febles
Rolf Erni
Affiliation:
FEI Electron Optics, PO Box 80066, 5600 KA Eindhoven, The Netherlands
Bert Freitag
Affiliation:
FEI Electron Optics, PO Box 80066, 5600 KA Eindhoven, The Netherlands
Peter Hartel
Affiliation:
CEOS GmbH, Englerstr. 28, D-69126 Heidelberg, Germany
Heiko Müller
Affiliation:
CEOS GmbH, Englerstr. 28, D-69126 Heidelberg, Germany
Peter Tiemeijer
Affiliation:
FEI Electron Optics, PO Box 80066, 5600 KA Eindhoven, The Netherlands
Michiel van der Stam
Affiliation:
FEI Electron Optics, PO Box 80066, 5600 KA Eindhoven, The Netherlands
Mike Stekelenburg
Affiliation:
FEI Electron Optics, PO Box 80066, 5600 KA Eindhoven, The Netherlands
Dominique Hubert
Affiliation:
FEI Electron Optics, PO Box 80066, 5600 KA Eindhoven, The Netherlands
Petra Specht
Affiliation:
Materials Science Division, Lawrence Berkeley National Laboratory, University of California, One Cyclotron Road, Berkeley, CA 94720, USA
Vincente Garibay-Febles
Affiliation:
Programma de Ingeniería Molecular, Instituto Mexicano del Petróleo, C.P. 07730 México D.F., México
Get access

Abstract

Planar defects in a polycrystalline diamond film were studied by high-resolution transmission electron microscopy (HRTEM) and high-resolution scanning transmission electron microscopy (STEM). In both modes, sub-Ångström resolution was achieved by making use of two aberration-corrected systems; a TEM and a STEM CS-corrected microscope, each operated at 300 kV. For the first time, diamond in 〈110〉 zone-axis orientation was imaged in STEM mode at a resolution that allows for resolving the atomic dumbbells of carbon at a projected interatomic distance of 89 pm. Twin boundaries that show approximately the Σ3 CSL structure reveal at sub-Ångström resolution imperfections; that is, local distortions, which break the symmetry of the ideal Σ3 type twin boundary, are likely present. In addition to these imperfect twin boundaries, voids on the atomic level were observed. It is proposed that both local distortions and small voids enhance the mechanical toughness of the film by locally increasing the critical stress intensity factor.

Keywords

polycrystalline diamondaberration-corrected microscopyHR-TEMHR-STEMplanar defects
Type
Research Article
Information
Microscopy and Microanalysis , Volume 12 , Issue 6: Special Issue: Frontiers of Electron Microscopy in Materials Science , December 2006 , pp. 492 - 497
Copyright
© 2006 Microscopy Society of America

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

Blase, X., Lin, K., Canning, A., Louie, S.G., & Chrzan, D.C. (2000). Structure and energy of the 90° partial dislocation in diamond: A combined ab initio and elasticity theory analysis. Phys Rev Lett 84, 5780–5783.Google Scholar
Delclos, S., Dorignac, D., Philipp, F., Moulin, S., & Bonnot, A.M. (1999). UHREM investigation of stacking fault interactions in the CVD diamond structure. Diamond Relat Mater 8, 682–687.Google Scholar
Delclos, S., Dorignac, D., Philipp, F., Silva, F., & Gicquel, A. (1998). Ultra-high resolution electron microscopy of defects in the CVD diamond structure. Diamond Relat Mater 7, 222–227.Google Scholar
Kaiser, U., Müller, D.A., Grazul, J.L., Chuvilin, A., & Kawasaki, M. (2002). Direct observation of defect-mediated cluster nucleation. Nat Mater 1, 102–105.Google Scholar
Nellist, P.D. & Pennycook, S.J. (2000). The principles and interpretation of annular dark-field atomic Z-contrast imaging. Adv Imag Electron Phys 113, 147–203.Google Scholar
Sawada, H. & Ichinose, H. (2005). Atomic structure of fivefold twin center in diamond film. Diamond Relat Mater 14, 109–112.Google Scholar
Valladares, A., Petford-Long, A.K., & Sutton, A.P. (1999). The core reconstruction of the 90° partial dislocation in silicon. Philos Mag Lett 79, 9–17.Google Scholar
Van der Stam, M.A., Tiemeijer, P., Freitag, B., Stekelenburg, M., & Ringnalda, J. (2005). The design and first results of a dedicated corrector (S)TEM. Microsc Microanal 11 (S02), 2148–2149.Google Scholar
Wang, S., Borisevich, A.Y., Rashkeev, S.N., Glazoff, M.V., Sohlberg, K., Pennycook, S.J., & Pantelides, T. (2004). Dopants absorbed as single atoms prevent degradation of catalysts. Nat Mater 3, 143–146.Google Scholar