Hostname: page-component-84b7d79bbc-7nlkj Total loading time: 0 Render date: 2024-07-25T14:06:25.587Z Has data issue: false hasContentIssue false
  • English
  • Français

Low Temperature Synthesis of Polycrystalline Diamond by Microwave Plasma-Enhanced Chemical Vapor Deposition

Published online by Cambridge University Press:  21 February 2011

R. Ramesham ,
C. Ellis ,
T. Roppel ,
D.A. Jaworske  and
W. Baugh
R. Ramesham
Affiliation:
Electrical Engineering Department Alabama Microelectronics Scienceand Technology Center Auburn University, AL 36849–5201
C. Ellis
Affiliation:
Electrical Engineering Department Alabama Microelectronics Scienceand Technology Center Auburn University, AL 36849–5201
T. Roppel
Affiliation:
Electrical Engineering Department Alabama Microelectronics Scienceand Technology Center Auburn University, AL 36849–5201
D.A. Jaworske
Affiliation:
Lewis Research Center National Aeronauticsand Space Administration Cleveland, OH 44135–3127
W. Baugh
Affiliation:
Electrical Engineering Department Alabama Microelectronics Scienceand Technology Center Auburn University, AL 36849–5201
Get access

Abstract

Polycrystalline diamond thin films have been deposited on single crystal silicon substrates at low temperatures (<950° C) using a mixture of methane and hydrogen gases by high pressure microwave plasma assisted chemical vapor deposition. Low temperature deposition has been achieved by cooling the substrate holder with nitrogen gas. For deposition at reduced substrate temperature, it has been found that nucleation of diamond will not occur unless methane/hydrogen ratio is increased significantly from its value at higher substrate temperature. Selective deposition of polycrystalline diamond thin films has been achieved at 600° C using our technique previously used at 930° C. Decrease in the diamond particle size and growth rate, and an increase in surface smoothness have been observed with decreasing substrate temperature during the growth of thin films. The morphology is analyzed by scanning electron microscopy and the as-deposited films are identified by Raman spectroscopy.

Type
Research Article
Information
MRS Online Proceedings Library (OPL) , Volume 190: Symposium M – Plasma Processing and Synthesis of Materials III , 1990 , 341
Copyright
Copyright © Materials Research Society 1991

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

1. Davidson, J.L., Ramesham, R., and Ellis, C., 176th Electrochemical Society Meeting, Hollywood, FL, Extended Abstract #682, Oct. 15–20, 1989 (submitted for publication in the J. Electrochem. Soc.)Google Scholar
2. Kaneko, H., Kamada, M., Kuwae, R., Sawabe, A., and Inuzuka, T., Appl. Surface Sci., 33/34, 546 (1988).Google Scholar
3. Saito, Y., Sato, K., Tanaka, H., Fujita, K., and Matuda, S., J. Mater. Sci., 23, 842 (1988).Google Scholar
4. Pinneo, M.J., Yokoto, S., and Ravi, K.V., Third Annual SDIO/IS T-ONR Diamond Technology Initiative Symposium, Crystal City, VA, Paper #T4 (1988).Google Scholar
5. Kitabatake, M. and Wasa, K., J. Appl. Phys., 58, 1693 (1985).Google Scholar
6. Deutchman, A.H., Partyka, R.J., and Lewis, J.C., Fourth Annual SDIO/IST-ONR Diamond Technology Initiative Symposium, Crystal City, VA, Paper #T3 (1989).Google Scholar
7. Deshpandey, C., Bunshah, R.F., Doerr, H.J., and Radhakrishna, M.C., Fourth Annual SDIO/IST-ONR Diamond Technology Initiative Symposium, Crystal City, VA, Paper #T4 (1989)Google Scholar
8. Liou, Y., Inspektor, A., Weimer, R., and Messier, R., Appl. Phys. Lett., 55, 631 (1989).Google Scholar
9. Hsu, W.L., Fuchs, E.A., and McCarty, K.F., Fourth Annual SDIO/IST-ONR Diamond Technology Initiative Symposium, Crystal City, VA, Paper #THP12a (1989).Google Scholar
10. Davidson, J.L., Ramesham, R., and Ellis, C., Fourth Annual SDIO/IST-ONR Diamond Technology Initiative Symposium, Crystal City, VA, Paper #TP3 (1989).Google Scholar
11. Davidson, J.L., Ellis, C., and Ramesham, R., J. Electron. Mater., 18 711 (1989).Google Scholar
12. Knight, D.S. and White, W.B., J. Mater. Res., 4, 385 (1989).Google Scholar
13. Plano, L.S. and Adar, F., Proc. S.P.I.E. - The International Society for Optical Engineering, International Conference on Raman and Luminescence Spectroscopy in Technology, 822,52 (1987).Google Scholar